Hostname: page-component-6bf8c574d5-t27h7 Total loading time: 0 Render date: 2025-02-15T09:56:01.721Z Has data issue: false hasContentIssue false
  • English
  • Français

Structural Changes in a-Si:H Films Deposited on the Edge of Crystallinity

Published online by Cambridge University Press:  15 February 2011

A.H. Mahan ,
J. Yang ,
S. Guha  and
D.L. Williamson
A.H. Mahan
Affiliation:
National Renewable Energy Laboratory, Golden CO 80401
J. Yang
Affiliation:
United Solar Systems Corp., Troy, MI 48084
S. Guha
Affiliation:
United Solar Systems Corp., Troy, MI 48084
D.L. Williamson
Affiliation:
Colorado School of Mines, Golden, CO 80401
Get access

Abstract

Using infrared, H evolution and x-ray diffraction (XRD), the structure of high H dilution, glow discharge deposited a-Si:H films ‘on the edge of crystallinity’ is examined. From the Si-H wag mode peak frequency and the XRD results, we postulate the existence of very small Si crystallites contained within the as-grown amorphous matrix, with the vast majority of the bonded H located on these crystallite surfaces. Upon annealing at ramp rates of 8-15°C/min, a H evolution peak at ~400°C appears, and film crystallization is observed at temperatures as low as 500°C, both of which are far below those observed for a-Si:H films grown without H dilution using similar rates. While the crystallite volume fraction is too small to be detected by XRD in the as-grown films, these crystallites enable the crystallization of the remainder of the amorphous matrix upon moderate annealing, thus explaining the existence of the low temperature H evolution peak.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 557: Symposium A – Amorphous and Heterogeneous Silicon Thin Films—Fundamentals to Devices—1999 , 1999 , 269
Copyright
Copyright © Materials Research Society 1999

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1. Guha, S., Narasimhan, K. L., and Pieruszko, S. M., J. Appl. Phys. 52 (1981) 859.Google Scholar
2. Kroll, U., Meier, J., Shah, A., Mikhailov, S., and Weber, J., J. Appl. Phys. 80 (1996) 4971.Google Scholar
3. Yang, J., Banerjee, A., and Guha, S., Appl. Phys. Lett. 70 (1997) 2975.Google Scholar
4. Tsu, D. V., Chao, B. S., Ovshinsky, S. R., Guha, S., and Yang, J., Appl. Phys. Lett. 71 (1997) 1317.Google Scholar
5. Cabarrocas, P. Roca i, Layadi, N., Heitz, T., Drevillon, B., and Solomon, I., Appl. Phys. Lett. 66 (1995) 3609.Google Scholar
6. Koh, J., Lee, Y., Fujiwara, H., Wronski, C. R., and Collins, R. W., Appl. Phys. Lett. 73 (1998) 1526.Google Scholar
7. Xu, X., Yang, J., and Guha, S., J. non-Cryst. Sol. 198–200 (1996) 60.Google Scholar
8. Guha, S., Yang, J., Williamson, D. L., Lubianiker, Y., Cohen, J. D., and Mahan, A. H., Appl.Phys. Lett. 74, 1999, in press.Google Scholar
9. Wagner, H. and Beyer, W., Solid State Comm. 48 (1983) 585.Google Scholar
10. Iverson, R. B. and Reif, R., J. Appl. Phys. 62 (1987) 1675.Google Scholar
11. Beyer, W., private communication.Google Scholar
12. Brodsky, M. H., Cardona, M., and Cuomo, J. J., Phys. Rev. B 16 (1977) 3556.Google Scholar
13. Beyer, W., in Semiconductors and Semimetals, Nickel, N., Ed. (Academic Pr., 1999), p.165.Google Scholar
14. Schaefer, J. A., Balster, T., Polyakov, V., Rossow, U., Sloboshanin, S., Starke, U., and Tautz, F. S., MRS Proc. 513 (1998) 3.Google Scholar
15. Langford, A. A., Fleet, M. L., Nelson, B. P., Lanford, W. A., and Maley, N., Phys. Rev. B45 (1992) 13367.Google Scholar
16. Culbertson, R. J., Feldman, L. C., Silverman, P. J., and Haight, R., J. Vac.Sci. Tech. 20 (1982) 868.Google Scholar
17. Warren, B. E., X-Ray Diffraction, Dover Publications (New York, 1990), pg. 256.Google Scholar
18. Beyer, W., in Tetrahedrally Bonded Amorphous Semiconductors, Adler, D. and Fritzsche, H., Eds. (Plenum, 1985), pg. 129.Google Scholar
19. Mahan, A. H., Williamson, D. L., and Furtak, T. E., MRS Symp. Proc. 467 (1997) 657.Google Scholar
20. Rath, J. K., Barbon, A., and Schropp, R. E. I., J. non-Cryst. Solids 227–230, 1277 (1998).Google Scholar
21. Wu, Y., Stephen, J. T., Han, D. X., Rutland, J. M., Crandall, R. S., and Mahan, A. H., Phys. Rev. Lett. 77 (1996) 2049.Google Scholar