Hostname: page-component-6bf8c574d5-h6jzd Total loading time: 0.001 Render date: 2025-02-19T11:45:50.232Z Has data issue: false hasContentIssue false

The Relationship between Intrinsic Stress of Silicon Nitride Films and Ion Generation in A 50 KHz RF Discharge

Published online by Cambridge University Press:  22 February 2011

K. Aite
Affiliation:
University of Twente, ICE Lab., P.O.B. 217, 7500-AE Enschede, The Netherlands.
J. Holleman
Affiliation:
University of Twente, ICE Lab., P.O.B. 217, 7500-AE Enschede, The Netherlands.
J. Middelhoek
Affiliation:
University of Twente, ICE Lab., P.O.B. 217, 7500-AE Enschede, The Netherlands.
R. Koekoek
Affiliation:
Tempress BV., Marconistraat 14, 7903-AG Hoogeveen, The Netherlands.
Get access

Abstract

Silicon nitride films prepared by the Plasma Enhanced Chemical Vapor Deposition technique (PECVD) are widely used in microelectronics. The intrinsic stress value of the silicon nitride films is a key factor which determines their reliability. A low frequency (50 kHz) RF discharge and a N2/NH3 /SiH4 gas mixture were used to deposit silicon nitride films on 4-inch silicon wafers in a horizontal hot-wall reactor at a temperature of 350 °C.

The compressive stresses in the deposited films were found to increase linearly with the nitrogen ionization created in the glow discharge. The nitrogen ion bombardment at the film surface induces ion implantation into the deposited film which results in film expansion. The stresses were deduced by the interference fringes technique and from surface profiler measurements. Optical Emission Spectroscopy of the N2/NH3/SiH4 discharge was used for measuring the N+2 peak intensity variation with the partial pressure of the nitrogen gas.

When the nitrogen ionization was increased, a shift of the main infrared transmission peak corresponding to the Si-N bond in the silicon nitride films was observed using Fourier Transform Infrared Spectroscopy (FTIR). The Si-H and N-H infrared peaks in the films were not affected by the ion bombardment. A linear relationship was found between the wavenumber of the main infrared Si-N peak νM (835–875 cm−1) and the intrinsic stress σi of the deposited nitride films with the slope dνM/dσi −4.85×10−8 cm−1 /Pa.

Type
Research Article
Copyright
Copyright © Materials Research Society 1989

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

[1] Hollahan, J.R. and Rosier, R.S., in “Thin Film Processes”, edited by Vossen, J.L and Kern, W., Academic Press, N.Y., p. 335, (1978).CrossRefGoogle Scholar
[2] Claassen, W.A.P., Valkenburg, W.G.J.N., Willemsen, M.F.C., and Wijgert, W.M.v.d., J. Electrochem. Soc., 132, p. 893, April 1985.CrossRefGoogle Scholar
[3] Sinha, A.K., Levinstein, H.J., Smith, T.E., Quintana, G., Haszako, S.E., J. Electrochem. Soc., 125, pp. 601–8, (1978).CrossRefGoogle Scholar
[4] Thornton, J.A., In Deposition Technologies for Films and Coatings, ed. Bunshah, R.F., pp. 170243. Park Ridge: Noyes publications, (1982).Google Scholar
[5] Eernisse, E.P., J. Appl. Phys., 48, 3337–41, (1977).CrossRefGoogle Scholar
[6] Retajczyk, T.F. Jr., and Sinha, A.K., Thin Sol. Films, 70, 241 (1980).CrossRefGoogle Scholar
[7] Burkhardt, P.J. and Marvel, R.F., J. Electrochem. Soc., 116, 864 (1969).CrossRefGoogle Scholar
[8] “Physics of Thin Films”, Vol.2, pp.211273, edited by Haas, G. and Thun, R.F., Academic Press, New York (1966).Google Scholar
[9] Aite, K., Holleman, J., Middelhoek, J. and Koekoek, R., to be published in EURO CVD 7, Perpignan, France, 19–23 June 1989.Google Scholar
[10] Coburn, J.W. and Kay, E., J. Appl. Phys., 43, 4365 (1972).CrossRefGoogle Scholar
[11] Vossen, J.L., J. Electrochem. Soc., 126, 319 (1979).CrossRefGoogle Scholar
[12] Hirose, M., Semiconductors and Semimetals, Vol.21 A, Pankove, J.l., Ed., Academic Press, New York, p.12, (1984).Google Scholar
[13] Ando, K., Aozasa, M., Pyon, R.S., Appl. Phys. Lett., 44, pp. 413–15, 1984.CrossRefGoogle Scholar
[14] Winters, H.F., in “Topics in current Chemistry,” Veprek, S. and Venugopolan, M., Editors, Chap.3, p. 120, Plasma Chemistry III, Springer-Verlag, Berlin (1980).Google Scholar